FEATURED BUSES

FINAL BUS 130 POINT CERTIFICATION INPSECTION

AUDIO SYSTEM

Audio/cassette/CD system working normally,
Antenna is present and functions properly
Radio speakers do not rattle at high volume

Battery in good condition, has proper cold cranking amps and reserve capacity
Battery proper size and secure
Battery posts free of corrosion
Cables in good condition

Inspect brakes, calipers, lines and hoses
No excessive vibration during braking
ABS operates on "panic stop"
Parking brake sets and holds vehicle
Brake pads/shoes must have minimum of 95% wear remaining
No excessive grooving or heat checking of rotors or drums
Parking brake releases completely
Brake pedal free play and travel is normal

Perform emissions test and/or state inspection, if required

Change engine oil and filter
Inspect for fuel, oil, coolant or other fluid leaks
Engine cold high idle correct
No abnormal engine noise at cold start
Drivability OK during warm-up
Hot drivability OK
Engine reaches normal operating temperature
Engine fan functions properly
No excessive drone or vibration from engine
Drive belts and hoses free of cracks or damage
No damage to engine mounts
Check under-hood labels and decals
Engine compartment is clean
Inspect air filter
Oil, brake, clutch, transmission, washer and power steering fluid levels OK
Under-hood fluids clear and uncontaminated

Engine coolant at proper hot and cold levels
Coolant specific gravity to -31° Fahrenheit
A/C cooling operation normal
A/C refrigerant sight glass clear
Heater operation normal

Exterior is clean and free of road residue
No cracked or broken lenses of exterior lights
Outside rearview mirror operates/lens is good
Glass free of cracks, stars and chips
Glass is free of improper repairs
Bumpers are free of cuts, gouges and scratches
Body is free of all dents
Body is free of dings
Paint is free of scratches and chips
Hood latch working
Paint has even, high luster
Free of wax residue
Wheel wells are clean
Acceptable aftermarket items checked
Removal of unacceptable aftermarket items

Frame check
Inspect body surface
Inspect panel alignment and fit
Inspect lower body and underbody for damage
Check exhaust systems and hangers

Master key is present
Fuel gauge reads correctly
Battery voltage gauge reads correctly
Horn works
Airbag deployment/replaced airbag
Speedometer and odometer work properly
Cruise control operation normal
Clock keeps time
All wiper speeds work correctly
Windshield washer operates
Wiper blades are in good condition and work
Wipers return to correct position when OFF
All mirrors have full range of adjustment
Windows operate normally
Window locks operate normally
Power windows operate from master switch and all door switches

Window tinting clear and free of bubbles
Ashtrays and lighter are clean; no evidence of use
Headliner, sun visors, dash pad, upholstery, console, cup holders, trim panels, floor mats and carpets are in place and in good condition
Doors open and close correctly
Door locks, including child safety locks, work properly
Seats, including all position adjusters, work properly
Headrests function properly
Interior leather, vinyl, plastic, carpet and fabric surfaces are free of holes, rips, tears
Inspect seatbelt condition
Seatbelts have full range of extension and smooth operation
Seatbelts lock up per specification
Interior is free of debris
Dash and vents are clean and properly dressed
All crevices are clean
Doorjambs are clean
Glove box and console compartments are clean
Seats, carpets, floor mats and headliner are free of stains
Free of odor, including heavy perfume
Glass is clean and free of streaks

Warning lights function
High and low beams OK
Headlight aim is OK
Taillights work
Brake lights work
Side marker lights work
Backup lights work
License plate lights work
Instrument lights work
Dash light dimmer works
Turn signals operate correctly and self-cancel
Four-way flashers work
Dome/courtesy lights operate with door cycles
Steering has normal feel in lock-to-lock turning
Steering wheel centered in straight line driving
Vehicle tracks and drives straight on level surface
Tilt steering wheel adjustment works properly
No excessive wind whistle or buzz
No excessive tire vibration or steering wheel shimmy at any speed
Interior free of significant squeaks or rattles
Inspect steering rack, linkage, bushings, control arms and dust boots

Inspect tires for defects, damage and inflation
Minimum of 30/32" tread depth remaining across tread width
All six tires must be of same brand, model, size, tread design, speed and load rating
Wheels are clean and free of brake dust
Tires are dressed, not greasy
Wheel cover caps secure with no damage
Inspect struts/shocks for leaks and wear

Transmission/clutch operates smoothly
Automatic transmission in "ECT" power mode shifts properly
Transmission gear ranges engage promptly while shifting when warmed up
Transmission shift lock and key interlock system OK
Transmission does not shift into overdrive when button is in OFF position
Inspect transmission case and pan for leaks
No damage to drive shafts
Differential fluid level correct

VERIFY HISTORY

Check to make sure of vehicles history